TEXACO REFINING AND MARKETING INC

HOUSTON, TX 77002-3310 US

Telephone: 713-650-5206

Cage: 2R503

SOLVENT REFINED HYDROTREATED RESIDUAL OIL

CAS: 64742-57-0

Fraction By Weight: 35 - 46%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT DEWAXED (MILD),

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 50 - 61%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

OLEFIN SULFIDE

CAS: 72162-26-6

Fraction By Weight: 3 - 10%

ALKYLAMINE SALT OF PHOSPHORIC ACID ESTERS/ALKYLAMINES

CAS: 71888-91-0

Fraction By Weight: 1 - 3%

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS >20,000 MG/KG.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN. ACUTE-
EYE:DIRECT CONTACT IRRITATES SLIGHTLY. SKIN:PROLONGED/REPEATED
CONTACT MAY CAUSE IRRITATION. INJECTION UNDER SKIN CAUSES LOCAL
NECROSIS. INHALE:MAY CAUSE RESPIRATORY TR ACT IRRITATION, HEADACHE.
ORAL:IF MORE THAN SEVERAL MOUTHFULS ARE SWALLOWED, NAUSEA, DIARRHEA
MAY OCCUR. CHRONIC- NONE.
Explanation of Carcinogenicity:NONE.
Effects of Overexposure:IRRITATION, REDNESS, SWELLING, TISSUE DAMAGE,
NAUSEA, VOMITING, DIARRHEA, DISCOMFORT
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUCCEPTIBLE TO THE EFFECTS FROM EXPOSURE TO
THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:MOVE TO FRESH
AIR. EYES:FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN.
SKIN:WIPE OFF EXCESS & WASH SKIN WITH SOAP & WATER. IF INJECTED
UNDER SKIN, RE GARDLESS OF ITS SIZE, CONTACT A PHYSICIAN
IMMEDIATELY. DELAY MAY CAUSE LOSS OF AFFECTED PART OF BODY. ORAL:IF
MORE THAN SEVERAL MOUTHFULLS ARE SWALLOWED, DRINK 2 GLASSES OF
WATER. CALL PHYSICIAN.

Flash Point:360F,182C; COC

Spill Release Procedures:PICK-UP SPILL WITH INERT ABSORBENT MATERIAL
SUCH AS DIATOMACEOUS EARTH, SAND OR VERMICULITE. SWEEP UP AND
TRANSFER TO A CONTAINER FOR PROPER DISPOSAL. CLEAN AREA WITH MILD
DETERGENT AND WATER. REPORT IF MORE THAN 1,000,000 POUNDS ARE
SPILLED.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE AWAY FROM STRONG OXIDIZING
AGENTS. KEEP CONTAINERS TIGHTLY CLOSED. KEEP OUT OF REACH OF
CHILDREN. AVOID WATER CONTAMINATION.
Other Precautions:DO NOT GET IN EYES. MINIMIZE SKIN CONTACT. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED.

Respiratory Protection:NONE NORMALLY NEEDED. IF WORKING IN CONFINED
AREAS, IF EXCESSIVE MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES
EXCEED RECOMMENDED PERMISSIBLE EXPOSURE LIMITS, WEAR NIOSH-APPROVED
ORGANIC VAPOR AND MI ST RESPIRATOR (REFER TO 29 CFR 1910.134)
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:WASH AT MEALTIME AND END OF SHIFT.
Eye Protection:CHEMICAL GOGGLES RECOMMENDED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATIONS, SEE PNI A AND B, SAME NSN.
WHEN OVERHEATED, PRODUCT MAY RELEASE HYDROGEN SULFIDE GAS. AT
CONCENTRATIONS ABOVE 300 PPM, RESPIRATORY PARALYSIS, CAUSING UNCONS
CIOUSNESS AND DEATH CAN OCCUR.

Viscosity:14.2CST @212F

Hazardous Decomposition Products:SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE, ALDEHYDES, KETONES, HYDROGEN SULFIDE, PHOSPHORUS
COMPOUNDS, SULFUR COMPOUNDS

Product ID:MULTIGEAR LUBRICANT EP SAE 80 W-90,02316
MSDS Date:01/01/1987
FSC:9150
NIIN:01-313-2191
MSDS Number: CFLFN

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. THIS PRODUCT HAS BEEN EVALUATED FOR RCRA
CHARACTERISTICS AND DOES NOT MEET THE CRITERIA OF A HAZARDOUS WASTE
IF DISCARDED IN ITS PUR CHASED FORM.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.